deneme bonusu

New Machinery


Forging Industry Association logo

Save

Save

Share:

1.5GW consisting of (2) 750MW GE GT's 9FA.03 (DLN2)
+ 1 ST D11 combined cycle power plts, never used, Re:26194

26194

This extraordinary Power Plant has never been used.

We present this Plant, at a fraction of the price when sold new, as an opportunity!

Each module has two Gas turbines GE 9FA.03 (DLN2+) and one Steam Turbine GE D11. Each GT exhaust is directed to the triple pressure unfired, natural circulation horizontal, type CMI USA HRSG. This configuration helps turndown operation of station up to 45%.

The Station is based on robust design of GE Gas Turbine with high efficiency DLN2+ Dry low Nox system, each GT is site rated for an output of 235 MW and the triple pressure reheat GE D11 Steam Turbine with downstream Exhaust, is site rated at 266 MW.

The HRSG is a Triple pressure, Natural circulation, Horizontal design type with Deaerator atop the LP drum. Thus Net Combined cycle efficiency at Site condition is approx 57% on LHV basis. 

The inherent design of the gas turbine reduced the NOx emissions < 25 ppmvd. Noise level of the station is below 85 db. The machines operating frequency is 50 HZ and the power factor 0.85. 

The ambient conditions are:

Site elevation above MSL meter 27 Ambient temperature Deg Cº29 Relative humidity % 70` 

The Major operation parameters are:

  a.) Base load gas requirement per GT is 1.5 million standard cubic meter per day (mmscmd).

  b.) Base Load Gross heat Rate on GCV basis 1780 Kcal/kwh

  c.) Nominal Station Auxiliary power Consumption is < 3 %.

Used Power Plants
Note

Additional Info:

Gas Turbine Details:

Make                                                               :           General Electric, USA

Model                                                              :           PG 9351 FA.03

Fuel                                                                 :           Natural Gas

Combustion                                                    :           Dry Low NOx DLN 2.0+

Compressor Stage                                           :           18

Turbine Stage                                                 :           3

Operating Speed                                             :           3000 RPM

Trip Speed                                                      :           3300 RPM

Starting Means                                                :           Static Start

Air Filtration                                                   :           Self Cleaning

Inlet Air Cooling                                            :           Evaporative Cooler On/Off condition

Compressor Cleaning                                     :           Offline / Online

Enclosure                                                        :           Indoor

Cooling                                                           :           Closed Loop

Nox Emissions                                                :           Gas Fuel , 25 ppm ref 15% O2

 

Generator Details:

Manufacturer                                                  :           GE

Type                                                                :           324 LU

Prime Mover                                                   :           GT 9FA

Cooling Method                                              :           Hydrogen cooled.

Rated Capacity                                               :           310.725 MVA

Rated Terminal Voltage                                 :           15.75 kV

Rated stator current                                        :           11390 A

Rated power factor                                         :           0.85(lag), capability to 0.95 (lead)

Rated Speed                                                    :           3000 rpm

Rated Frequency                                             :           50Hz

No. of phase / Connection                              :           3 / Wye

Short Circuit Ratio (SCR)                              :           0.53

Excitation                                                        :           Static Bus Fed EX2100

Terminal Enclosure                                        :           On Top

Seal Oil System                                              :           Scavenging Design

 

Heat Recovery Steam Generator details:

Make                                                               :           CMI EPTI, USA

Type                                                                :           Horizontal, Natural Circulation, Triple-

                                                                                     Pressure

Parameters

HP

Reheater

IP

IP is ola table Economizer

IP

LP is ola table Economizer

Max. Allowable Working Pressure (Kg/cm2)

149.8

32.8

38.2

76.6

10.2

43.2

Heating Surface Area (m2)

153446

21122

33444

153446

38609

153446

Max Steaming Capacity (Kg/h)

292500

326500

50000

7853

38700

82580

 

HP/IP Boiler Feed Pump & Motor details:

Make                                                               :           Torishima

Type & Size                                                    :           MHB 5/11

Speed                                                              :           Variable Speed (nominal 2979 rpm)

Capacity                                                          :           352.9 m3/h

Design Pressure (bar A)                                 :           Extraction: 88.4; Discharge: 247.6

Hydraulic Balancing                                       :           Piston

Casing Type / Mount                          :           Diffuser / Centerline

External Casing                                              :           Barrel

Coupling                                                         :           Voith

 

Motor:

Make                                                               :           TECO Taiwan

Type                                                                :           AEZW, 6.6KV, 50Hz, 3 Ph

Method of Starting                                          :           DOL

Frame Size                                                      :           450E

Driver                                                              :           2700 kW

Degree of Protection of Enclosure                 :           IP55

Stator                                                              :           Wye

 

Condenser Extraction Pump & Motor details:

Make                                                               :           Torishima

Type & Size                                                    :           MMTV 250/5

Total Head                                                      :           295.6 m

Speed                                                              :           1485 rpm

Capacity                                                          :           949.3 m3/h

 

MOTOR:

Make                                                               :           TECO Taiwan

Type                                                                :           AEHC, 6.6KV, 50Hz, 3 Ph

Method of Starting                                          :           DOL

Frame Size                                                      :           500 C

Driver                                                              :           1060 kW

Degree of Protection of Enclosure                 :           IP55

Stator                                                              :           Wye

 

CW Pump & Motor details:

Make                                                               :           WPIL

Type                                                                :           Mixed flow non pull out

Model                                                              :           VT 49‐72

Total Head                                                      :           24 MWC

Speed                                                              :           424 rpm

Capacity                                                          :           23500 m3/h

 

Motor:

Make                                                               :           CGL

Type                                                                :           Squirrel Cage , 6.6KV , 50Hz, 3 Ph

Method of Starting                                          :           DOL

Frame Size                                                      :           VTPC 1700

Driver                                                              :           2100 kW

Degree of Protection of Enclosure                 :           IP55

Stator                                                              :           Wye

 

Steam Turbine details:

Make                                                               :           GE

Model                                                              :           D11

Type                                                                :           TC‐Down flow

Rated Speed                                                    :           3000 rpm

HP Steam Inlet                                               :           127 Kg/ Cm2 , 566 deg C

LP Stage Bucket Length                                 :           850.9 mm (33.5 inch)

Exhaust flow                                                   :           Down

Total no of stages:

High Pressure                         10

Intermediate Pressure             8

Low Pressure                          5

Number of Casings                 2

 

Generator details:

Manufacturer                                                  :           GE

Type                                                                :           324H

Prime Mover                                                   :           D11

Cooling Method                                              :           Hydrogen cooled

Rated Capacity                                               :           324.760 MVA

Rated Terminal Voltage                                 :           15.75 kV

Rated stator current                                        :           11904 A

Rated power factor                                         :           0.85(lag), capability to 0.95 (lead)

Rated Speed                                                    :           3000 rpm

Rated Frequency                                             :           50Hz

No. of phase / Connection                              :           3 / Wye

Excitation                                                        :           Static

Terminal Enclosure                                        :           Bottom

 

Excitation – GTG &STG details:

Type                                                                :           Static Excitation System

Model                                                              :           EX2100

 

Static Excitation Transformer

Type                                                                :           Oil filled

Power Rating                                                  :           2500 kVA

No‐Load Voltage (HV/LV)                            :           6600/900 V

Rated Current (HV/LV)                                  :           219/1604 Amps

No of Phases                                                   :           3

Frequency                                                       :           50 Hz

 

Static Starting System for GT Units details:

Load Commutated Inverter (LCI)

Make / Model No.                                          :           LS2100

Power Rating                                                  :           14MVA

Input Voltage                                                  :           2080 Vrms

Input Frequency                                              :           50Hz

 

Isolation Transformer (LCI Transformer)

Type                                                                :           Oil filled

Power Rating (HV/LV1/LV2)                        :           7/3.5/3.5 MVA

No‐Load Voltage (HV/LV1/LV2)                  :           6600/2080/2080 V

Rated Current (HV/LV1/LV2)                       :           612/972/972 Amps

No of Phases                                                   :           3

Frequency                                                       :           50 Hz

 

Generator Circuit Breaker details:

Make                                                               :           ABB

Type                                                                :           SF6

Model No.                                                       :           HECS‐1OOL Plus

Quantity                                                          :           2 No’s

Service                                                                        :           Indoor

Rated Voltage                                                 :           25.3 KV

Rated Frequency                                             :           50 Hz

Rated Continuous current                               :           13,000 A

Rated Duty Cycle                                           :           CO‐30Min‐CO

Number of trip coils                                       :           2

Interrupting medium                                       :           SF6

 

Generator Bus Duct details:

Type                                                                :           Isolated phase, continuous

Service                                                                        :           Indoor / Outdoor

Rated Voltage                                                 :           17.5 KV

Current rating

Main run                                             :           13000 A

Tap off run                                          :           1300 A

Conductor                                                       :           Aluminum alloy

Enclosure                                                        :           Aluminum

Type of cooling                                              :           Air natural

 

Generator Step up Transformer details:

Make                                                               :           Hyundai

Type                                                                :           Oil Filled

Type of Cooling                                              :           ODAF/ONAF/ONAN

Rated Output                                                   :           335/268/201 MVA

Rated Voltage‐HV/LV                                   :           420 / 15.75 kV

No of Phases                                                   :           3

Frequency                                                       :           50Hz

 

Unit Auxiliary Transformer details:

Make                                                               :           Areva

Type                                                                :           Oil Filled

Type of Cooling                                              :           ONAF/ONAN

Rated Output                                                   :           31.5/25 MVA

Rated Voltage‐HV/LV                                   :           15.75 / 6.9 KV

Rated Current HV/LV                                     :           1154.7A /2635.7A

No of Phases                                                   :           3

Frequency                                                       :           50Hz

 

Condenser details:

Manufacturer                                                  :           HBG

Type                                                                :           Non Deaerating surface‐ two pass

No. of passes on tube side                              :           2

Size                                                                 :           23800 m2

Source of Water                                              :           Cooling Water

Cooling Water Flow Rate                               :           42849 m3/h

Shell material                                                  :           SA 516 Gr. 71

Tube material                                                  :           SA249 TP 304

Tube size                                                         :           25.4 mm OD ( 0.7 mm thick)

No. of Tubes                                                   :           11600

Condensate Flow                                            :           732 tph

 

Condenser details:

Manufacturer                                                  :           HBG

Type                                                                :           Non Deaerating surface‐ two pass

No. of passes on tube side                              :           2

Size                                                                 :           23800 m2

Source of Water                                              :           Cooling Water

Cooling Water Flow Rate                               :           42849 m3/h

Shell material                                                  :           SA 516 Gr. 71

Tube material                                                  :           SA249 TP 304

Tube size                                                         :           25.4 mm OD ( 0.7 mm thick)

No. of Tubes                                                   :           11600

Condensate Flow                                            :           732 tph

 

Cooling Tower details:

Make                                                               :           Hamon

Type of Fill                                                     :           Splash type

Nos. of Cells per tower                                   :           18

Cell Dimensions                                             :           15.75 m x 15.75 m

Fill Height                                                       :           5.6 m

Fan Diameter                                                  :           9144mm

 

Cooling Tower Gear Box

Make                                                               :           SUMITMO Heavy Industries

Model No.                                                       :           YVD050R2‐RRFB‐11.375

No of Gear Box                                              :           18 No’s

High Rotation Speed                                      :           1480 RPM

Low Rotation Speed                                       :           130.1 RPM

 

Drive Motor:

Make                                                               :           WEG Industria SA

Type                                                                :           Sq. Cage Induction

Model                                                              :           280 S/M

Rated output, KW                                           :           75

Voltage/Phase/Freq                                        :           415V/3Ph/50 Hz/ 125 A

Insulation Class                                              :           Class F

Speed, RPM                                                    :           1480

 

FIRE PROTECTION & DETECTION SYSTEM

 

S.NO

Parameter

Hydrant Pump

Spray Pump

Jockey Pump

1

Number of pumps

3

2

2

2

Number of pumps Working / standby

2W + 1S

1W + 1S

1W + 1S

3

Type of drives

 

 

 

3.1

Motor driven

2

1

2

3.2

Diesel engine driven

1

1

NA

 

Reserve Auxiliary Transformer (RAT or SUT) details:

Make                                                               :           Areva

Type                                                                :           Oil Filled

Type of Cooling                                              :           ONAF/ONAN

Rated Output MVA                                        :           31.5/ 25

Rated Voltage‐HV/LV KV                             :           400 / 6.9

Rated Current HV/LV  A                               :           45.52A / 2638.85 (ONAF)

:           36.13 / 2094.33 (ONAN)

No of Phases                                                   :           3

Frequency                                                       :           50Hz

 

6.6kV Switchgear details:

Make                                                               :           L&T

Type                                                                :           Vacuum, draw out

Service                                                                        :           Indoor

Rated voltage                                                  :           6600V, 3 phase, 3 wire

Lightning impulse withstand voltage             :           60 KV (peak)

Power frequencywithstands voltage               :           20 KV (rms)

Short time rating                                             :           31.5 KA (Sym) for 1 sec

 

Circuit Breaker

Type                                                                :           Vacuum

Number of poles                                             :           Three

 

Emergency Diesel Genset details:

DG set manufacturers name                           :           M/s SterIing Wilson Power gen Pvt. Ltd.

DG set model no. offered                               :           SGP 1250 P

DG set output at 0.8 pf                                   :           1250 KVA

DG set output voltage                                     :           415V, 3 phase & neutral

DG set output frequency                                 :           50Hz

Diesel engine & alternator shaft speed           :           1500 rpm

Make of Diesel Engine                                   :           PERKINS

Model No. of Diesel Engine                           :           4012 PERKINS

Number of Cylinders                                      :           12 No’s vee, 60 Deg

Starting system                                               :           24 V DC Electric Starting System

Rotation direction                                           :           Anticlockwise

Excitation Voltage                                          :           40 V

 

400KV GIS

Supplier                                                          :           Xian , China

Quantity                                                          :           23 Bays

Rated voltage                                                  :           420 kV

Rated Frequency                                             :           50 Hz

Rated current                                                  :           5000A (Outlet & Inlet)

Rated power frequency 1 min withstand        :           680 KV

Voltage phase to earth

Rated lighting impulse withstand volt            :           1550KV

Peak 1.250 μs (Phase to earth)          

Power supply (control Circuit)                       :           220V DC

SF6 Pressure                                                   :           0.5 MPa

 

Control System for Gas Turbine Generator and Steam Turbine Generator details:

Make                                                               :           General Electric

Model                                                              :           Mark VIE

Type                                                                :           Triple Modular Redundant (TMR)

Control Network                                             :           Dual Redundant 10/ 100MB Ethernet

                                                                                    Network

System Details                                                :           Mark VIe Panels for each GTG located in Local container (PEECC) andMark VIe Panels for each STG are located in Central Electrical Room.

 

Control System for Station Balance of Plant details:

Make                                                               :           Honey well DCS

System Details                                                :           Control hardware located in the CER. HMI

                                                                                    Located in CCR


Used Power Plants
Specifications
Rating
1500MW
1500MW
 
Type
Combined Cycle
Combined Cycle
 
Manufacturer
GE
GE
 
Model
9FA.03 (DLN2) + 1 ST D11
9FA.03 (DLN2) + 1 ST D11
 
Fuel
Natrual Gas
Natrual Gas
 
Hz
50
50
 
Ref #
26194
26194
 
Note

Additional Info:

Gas Turbine Details:

Make                                                               :           General Electric, USA

Model                                                              :           PG 9351 FA.03

Fuel                                                                 :           Natural Gas

Combustion                                                    :           Dry Low NOx DLN 2.0+

Compressor Stage                                           :           18

Turbine Stage                                                 :           3

Operating Speed                                             :           3000 RPM

Trip Speed                                                      :           3300 RPM

Starting Means                                                :           Static Start

Air Filtration                                                   :           Self Cleaning

Inlet Air Cooling                                            :           Evaporative Cooler On/Off condition

Compressor Cleaning                                     :           Offline / Online

Enclosure                                                        :           Indoor

Cooling                                                           :           Closed Loop

Nox Emissions                                                :           Gas Fuel , 25 ppm ref 15% O2

 

Generator Details:

Manufacturer                                                  :           GE

Type                                                                :           324 LU

Prime Mover                                                   :           GT 9FA

Cooling Method                                              :           Hydrogen cooled.

Rated Capacity                                               :           310.725 MVA

Rated Terminal Voltage                                 :           15.75 kV

Rated stator current                                        :           11390 A

Rated power factor                                         :           0.85(lag), capability to 0.95 (lead)

Rated Speed                                                    :           3000 rpm

Rated Frequency                                             :           50Hz

No. of phase / Connection                              :           3 / Wye

Short Circuit Ratio (SCR)                              :           0.53

Excitation                                                        :           Static Bus Fed EX2100

Terminal Enclosure                                        :           On Top

Seal Oil System                                              :           Scavenging Design

 

Heat Recovery Steam Generator details:

Make                                                               :           CMI EPTI, USA

Type                                                                :           Horizontal, Natural Circulation, Triple-

                                                                                     Pressure

Parameters

HP

Reheater

IP

IP is ola table Economizer

IP

LP is ola table Economizer

Max. Allowable Working Pressure (Kg/cm2)

149.8

32.8

38.2

76.6

10.2

43.2

Heating Surface Area (m2)

153446

21122

33444

153446

38609

153446

Max Steaming Capacity (Kg/h)

292500

326500

50000

7853

38700

82580

 

HP/IP Boiler Feed Pump & Motor details:

Make                                                               :           Torishima

Type & Size                                                    :           MHB 5/11

Speed                                                              :           Variable Speed (nominal 2979 rpm)

Capacity                                                          :           352.9 m3/h

Design Pressure (bar A)                                 :           Extraction: 88.4; Discharge: 247.6

Hydraulic Balancing                                       :           Piston

Casing Type / Mount                          :           Diffuser / Centerline

External Casing                                              :           Barrel

Coupling                                                         :           Voith

 

Motor:

Make                                                               :           TECO Taiwan

Type                                                                :           AEZW, 6.6KV, 50Hz, 3 Ph

Method of Starting                                          :           DOL

Frame Size                                                      :           450E

Driver                                                              :           2700 kW

Degree of Protection of Enclosure                 :           IP55

Stator                                                              :           Wye

 

Condenser Extraction Pump & Motor details:

Make                                                               :           Torishima

Type & Size                                                    :           MMTV 250/5

Total Head                                                      :           295.6 m

Speed                                                              :           1485 rpm

Capacity                                                          :           949.3 m3/h

 

MOTOR:

Make                                                               :           TECO Taiwan

Type                                                                :           AEHC, 6.6KV, 50Hz, 3 Ph

Method of Starting                                          :           DOL

Frame Size                                                      :           500 C

Driver                                                              :           1060 kW

Degree of Protection of Enclosure                 :           IP55

Stator                                                              :           Wye

 

CW Pump & Motor details:

Make                                                               :           WPIL

Type                                                                :           Mixed flow non pull out

Model                                                              :           VT 49‐72

Total Head                                                      :           24 MWC

Speed                                                              :           424 rpm

Capacity                                                          :           23500 m3/h

 

Motor:

Make                                                               :           CGL

Type                                                                :           Squirrel Cage , 6.6KV , 50Hz, 3 Ph

Method of Starting                                          :           DOL

Frame Size                                                      :           VTPC 1700

Driver                                                              :           2100 kW

Degree of Protection of Enclosure                 :           IP55

Stator                                                              :           Wye

 

Steam Turbine details:

Make                                                               :           GE

Model                                                              :           D11

Type                                                                :           TC‐Down flow

Rated Speed                                                    :           3000 rpm

HP Steam Inlet                                               :           127 Kg/ Cm2 , 566 deg C

LP Stage Bucket Length                                 :           850.9 mm (33.5 inch)

Exhaust flow                                                   :           Down

Total no of stages:

High Pressure                         10

Intermediate Pressure             8

Low Pressure                          5

Number of Casings                 2

 

Generator details:

Manufacturer                                                  :           GE

Type                                                                :           324H

Prime Mover                                                   :           D11

Cooling Method                                              :           Hydrogen cooled

Rated Capacity                                               :           324.760 MVA

Rated Terminal Voltage                                 :           15.75 kV

Rated stator current                                        :           11904 A

Rated power factor                                         :           0.85(lag), capability to 0.95 (lead)

Rated Speed                                                    :           3000 rpm

Rated Frequency                                             :           50Hz

No. of phase / Connection                              :           3 / Wye

Excitation                                                        :           Static

Terminal Enclosure                                        :           Bottom

 

Excitation – GTG &STG details:

Type                                                                :           Static Excitation System

Model                                                              :           EX2100

 

Static Excitation Transformer

Type                                                                :           Oil filled

Power Rating                                                  :           2500 kVA

No‐Load Voltage (HV/LV)                            :           6600/900 V

Rated Current (HV/LV)                                  :           219/1604 Amps

No of Phases                                                   :           3

Frequency                                                       :           50 Hz

 

Static Starting System for GT Units details:

Load Commutated Inverter (LCI)

Make / Model No.                                          :           LS2100

Power Rating                                                  :           14MVA

Input Voltage                                                  :           2080 Vrms

Input Frequency                                              :           50Hz

 

Isolation Transformer (LCI Transformer)

Type                                                                :           Oil filled

Power Rating (HV/LV1/LV2)                        :           7/3.5/3.5 MVA

No‐Load Voltage (HV/LV1/LV2)                  :           6600/2080/2080 V

Rated Current (HV/LV1/LV2)                       :           612/972/972 Amps

No of Phases                                                   :           3

Frequency                                                       :           50 Hz

 

Generator Circuit Breaker details:

Make                                                               :           ABB

Type                                                                :           SF6

Model No.                                                       :           HECS‐1OOL Plus

Quantity                                                          :           2 No’s

Service                                                                        :           Indoor

Rated Voltage                                                 :           25.3 KV

Rated Frequency                                             :           50 Hz

Rated Continuous current                               :           13,000 A

Rated Duty Cycle                                           :           CO‐30Min‐CO

Number of trip coils                                       :           2

Interrupting medium                                       :           SF6

 

Generator Bus Duct details:

Type                                                                :           Isolated phase, continuous

Service                                                                        :           Indoor / Outdoor

Rated Voltage                                                 :           17.5 KV

Current rating

Main run                                             :           13000 A

Tap off run                                          :           1300 A

Conductor                                                       :           Aluminum alloy

Enclosure                                                        :           Aluminum

Type of cooling                                              :           Air natural

 

Generator Step up Transformer details:

Make                                                               :           Hyundai

Type                                                                :           Oil Filled

Type of Cooling                                              :           ODAF/ONAF/ONAN

Rated Output                                                   :           335/268/201 MVA

Rated Voltage‐HV/LV                                   :           420 / 15.75 kV

No of Phases                                                   :           3

Frequency                                                       :           50Hz

 

Unit Auxiliary Transformer details:

Make                                                               :           Areva

Type                                                                :           Oil Filled

Type of Cooling                                              :           ONAF/ONAN

Rated Output                                                   :           31.5/25 MVA

Rated Voltage‐HV/LV                                   :           15.75 / 6.9 KV

Rated Current HV/LV                                     :           1154.7A /2635.7A

No of Phases                                                   :           3

Frequency                                                       :           50Hz

 

Condenser details:

Manufacturer                                                  :           HBG

Type                                                                :           Non Deaerating surface‐ two pass

No. of passes on tube side                              :           2

Size                                                                 :           23800 m2

Source of Water                                              :           Cooling Water

Cooling Water Flow Rate                               :           42849 m3/h

Shell material                                                  :           SA 516 Gr. 71

Tube material                                                  :           SA249 TP 304

Tube size                                                         :           25.4 mm OD ( 0.7 mm thick)

No. of Tubes                                                   :           11600

Condensate Flow                                            :           732 tph

 

Condenser details:

Manufacturer                                                  :           HBG

Type                                                                :           Non Deaerating surface‐ two pass

No. of passes on tube side                              :           2

Size                                                                 :           23800 m2

Source of Water                                              :           Cooling Water

Cooling Water Flow Rate                               :           42849 m3/h

Shell material                                                  :           SA 516 Gr. 71

Tube material                                                  :           SA249 TP 304

Tube size                                                         :           25.4 mm OD ( 0.7 mm thick)

No. of Tubes                                                   :           11600

Condensate Flow                                            :           732 tph

 

Cooling Tower details:

Make                                                               :           Hamon

Type of Fill                                                     :           Splash type

Nos. of Cells per tower                                   :           18

Cell Dimensions                                             :           15.75 m x 15.75 m

Fill Height                                                       :           5.6 m

Fan Diameter                                                  :           9144mm

 

Cooling Tower Gear Box

Make                                                               :           SUMITMO Heavy Industries

Model No.                                                       :           YVD050R2‐RRFB‐11.375

No of Gear Box                                              :           18 No’s

High Rotation Speed                                      :           1480 RPM

Low Rotation Speed                                       :           130.1 RPM

 

Drive Motor:

Make                                                               :           WEG Industria SA

Type                                                                :           Sq. Cage Induction

Model                                                              :           280 S/M

Rated output, KW                                           :           75

Voltage/Phase/Freq                                        :           415V/3Ph/50 Hz/ 125 A

Insulation Class                                              :           Class F

Speed, RPM                                                    :           1480

 

FIRE PROTECTION & DETECTION SYSTEM

 

S.NO

Parameter

Hydrant Pump

Spray Pump

Jockey Pump

1

Number of pumps

3

2

2

2

Number of pumps Working / standby

2W + 1S

1W + 1S

1W + 1S

3

Type of drives

 

 

 

3.1

Motor driven

2

1

2

3.2

Diesel engine driven

1

1

NA

 

Reserve Auxiliary Transformer (RAT or SUT) details:

Make                                                               :           Areva

Type                                                                :           Oil Filled

Type of Cooling                                              :           ONAF/ONAN

Rated Output MVA                                        :           31.5/ 25

Rated Voltage‐HV/LV KV                             :           400 / 6.9

Rated Current HV/LV  A                               :           45.52A / 2638.85 (ONAF)

:           36.13 / 2094.33 (ONAN)

No of Phases                                                   :           3

Frequency                                                       :           50Hz

 

6.6kV Switchgear details:

Make                                                               :           L&T

Type                                                                :           Vacuum, draw out

Service                                                                        :           Indoor

Rated voltage                                                  :           6600V, 3 phase, 3 wire

Lightning impulse withstand voltage             :           60 KV (peak)

Power frequencywithstands voltage               :           20 KV (rms)

Short time rating                                             :           31.5 KA (Sym) for 1 sec

 

Circuit Breaker

Type                                                                :           Vacuum

Number of poles                                             :           Three

 

Emergency Diesel Genset details:

DG set manufacturers name                           :           M/s SterIing Wilson Power gen Pvt. Ltd.

DG set model no. offered                               :           SGP 1250 P

DG set output at 0.8 pf                                   :           1250 KVA

DG set output voltage                                     :           415V, 3 phase & neutral

DG set output frequency                                 :           50Hz

Diesel engine & alternator shaft speed           :           1500 rpm

Make of Diesel Engine                                   :           PERKINS

Model No. of Diesel Engine                           :           4012 PERKINS

Number of Cylinders                                      :           12 No’s vee, 60 Deg

Starting system                                               :           24 V DC Electric Starting System

Rotation direction                                           :           Anticlockwise

Excitation Voltage                                          :           40 V

 

400KV GIS

Supplier                                                          :           Xian , China

Quantity                                                          :           23 Bays

Rated voltage                                                  :           420 kV

Rated Frequency                                             :           50 Hz

Rated current                                                  :           5000A (Outlet & Inlet)

Rated power frequency 1 min withstand        :           680 KV

Voltage phase to earth

Rated lighting impulse withstand volt            :           1550KV

Peak 1.250 μs (Phase to earth)          

Power supply (control Circuit)                       :           220V DC

SF6 Pressure                                                   :           0.5 MPa

 

Control System for Gas Turbine Generator and Steam Turbine Generator details:

Make                                                               :           General Electric

Model                                                              :           Mark VIE

Type                                                                :           Triple Modular Redundant (TMR)

Control Network                                             :           Dual Redundant 10/ 100MB Ethernet

                                                                                    Network

System Details                                                :           Mark VIe Panels for each GTG located in Local container (PEECC) andMark VIe Panels for each STG are located in Central Electrical Room.

 

Control System for Station Balance of Plant details:

Make                                                               :           Honey well DCS

System Details                                                :           Control hardware located in the CER. HMI

                                                                                    Located in CCR